SeaKnots

I purchased a new 2008 Beneteau 40. This was an upgrade from my Oceanis 390, which was probably the finest boat I ever owned. I like the boat. Its easy to sail singlehanded and sails well, roomy, and has navionics to die for. However, its been a quality control nightmare. My dealer has been very good at getting things fixed, but the very fact that it left the factory with these kind of problems is quite amazing.

 

My last "issue" is the subject of this query. Shortly after delivery I noticed some "hairline" cracks in the gelcoat. The first appeared on the curved part of the deck on the starboard aft side in the curved part as it accends toward the cockpit. There were also several cracks begining to appear in various areas of the cockpit to include the cockpit table access doors.These were very noticeable and were actually cracked entirely through the doors. The dealer replaced the doors, and declared that we should "keep an eye on the other ones". I agreed with this assessment since they were barely noticeable. At this time we also noticed a small "chip" (very small) on the non-skid decking just outboard of the starboard helm on the flat part. It looked as if someone stabbed it with a sharp object from below. A crack was begining to appear, but again it was very small. I could only think that a wayward line with a shackle perhaps smacked it.

 

Long story short, the cracks have further materialized and more have appeared in the cockpit. The one on the decking now lhas completely spiderwebed and looks as if you droped a wrench on a mirror. I then looked at the port side and it became clear that it was right over the aft bulkhead on both sides. It was not rocket science to conclude that the deck was "pressed" into position over a bulhead that was too high. The commissioning boatyard and Beneteau themselves came to the same conclusion without my input.

 

To relate Beneteau's solution, and who is to pay for it is probably inappropriate at this time, but my limited research thus far has turned up others that have this problem. My guess is that there are more to come as well as the boat is still relatively new. The initial cracks appeared very quickly after delivery, but took about a year to develop to point that I knew this would be an issue.

 

I would suggest that owners check these areas. I would also appreciate knowing if this has been a problem for anyone else.

 

Thank you!

 

Charles

Views: 471

Reply to This

Replies to This Discussion

Charles
Have you seen my problems in the section http://seaknots.ning.com/group/beneteau4043/forum ?

We had those cracks to ... Beneteau fixed them all ... and we hope that they wont come back.
also I mentioned there other problems concerning our boat from the beginning 2009 french production.

Nice to hear that also others have those problems :-)
Alan,

Thank you for the reply. I followed your link but cannot see where you mention the cracks. Could you please explain your problem and the fix. I purchased mine in Seattle as well. The dealer has been pretty good getting things fixed, but this one their trying to site the "out of waranty" BS.

We also had the electrical problems. The battery isolator was improperly installed on the 40. It was shorting directly to ground. We went through 3 alternators and regulators. It burned out about everything electrical before they got it fixed. I bought a portable inverter and it ran almost all the time just to keep the batteries charged.

I would like to know more about the cracks

Thanks

Charles
Charles
check this http://seaknots.ning.com/group/beneteau4043/forum/topics/new-boat-n...


actually, the official technician (Pascal) from Beneteau France (the one from the Beneteau shipyard) is our best friend and well integrated into our little family :-) (he always has to do more than 1000 km from France to Slovenia... fortunately he fell in love with Slovenian wine)

RSS

Latest Activity

Robert & Sandy replied to sam's discussion eyebrow salon window re-bed in the group Beneteau 40 & 43
"Hello all, I realise coming into this year old conversation could be somewhat strange though sharing advice is always beneficial.. Our B43 had her port large saloon window repaired under warranty after it developed a gap and obvious leak. The boat…"
Mar 12
dryfirewood is now a member of SeaKnots
Mar 4
zeehag left a comment for ___/)ances With Sails
"bubba died  but he seems tohave sent a nother special boy to me..a scared  confuzed precious  with name pusskins which i changed  to sir puurrcival pusskins.  much more refined name for such a precious furry one.  he is…"
Mar 3
___/)ances With Sails commented on LOLA's group SAILBOATS and SLIPS FOR SALE
"My boats for sale. Search Craigslist/New Orleans/S211_A"
Feb 22
___/)ances With Sails left a comment for Lola
"Happy belated holidays!  I'll email you. "
Feb 22
___/)ances With Sails left a comment for zeehag
"Karen!! Dang!!!!  How did Bubba use up 9 lives already? Sorry to read that, kid."
Feb 22
olivia scott updated their profile
Feb 11
olivia scott is now a member of SeaKnots
Feb 9
ADVERTISE ON SEAKNOTS CONTACT US AT: 
candrac@sailforwater.com

© 2024   Created by CAN DRAC.   Powered by

Badges  |  Report an Issue  |  Terms of Service